Put in new fuse it blew. However, I'm not really surprised about that. I did not receive this notice and should still be able to get this repair done for free. The vehicle was merged to the shoulder, turned off and then restarted after several minutes, as it resumed normal operation. Isn't Ford a big enough company to take care of this instead of ignoring it? also, check the battery. Pulled over, turned the ignition off and back on and it was fine. The vehicle was taken to a dealer where it was diagnosed that the electronic throttle body sensor failed . The contact owns a 2005 Ford Five Hundred ltd. This is a flaw w Ford 500 2005 throttle body many complaints and test does never issues recall, unsafe. My car started chugging and running rough so I figured it was another coil. The failure mileage was 60,000 and the current mileage was 80,000. I have had myself and two other mechanics working on this thing.. Cars have become way overly complicated and in so become very untrustworthy. The car will lurch forward, the lights on the dashboard will all light up, and then the engine will shut down causing us to have to shift into neutral and try to pull over to safety. DANGEROUS!!! My next stop was to get two propane tanks filled. Expect the throttle body needs to be replaced but don't want to spend any more money on "diagnostics" when Ford knows this is a problem part and they need to stand behind it!!!!! The vehicle was totaled by the insurance company. This, as well as no speedometer to me is very dangerous. The fail safe mode warning light started to illuminate. If I am on the freeway running 70 mph, get off the ramp and the engine stalls. There was no power steering and I believe I could have had an accident if I wasn't strong enough to turn the steering wheel in order to get off the road. . 6.0 randomly shuts off - Ford Truck Enthusiasts Forums 2005 Ford Five Hundred - Why does car keep cutting off while driving? I think it's worth noting that this car had been treated well with oil changes every 3,000 miles and regular maintenance and checkups. Because of the many possible causes, it is important to diagnose it properly. I have changed the fuel filter and that has helped in for a week or so then it does it again. Drive foot on brake, rpms shot up engine reeves cat lunged forward I pressed harder in brake almost hit person. It should never be in control of moving by itself when the brakes are applied. Engine Stalls/Shuts Off While Driving 2005 Ford Explorer This problem may be covered under warranty. Took it to the mechanic the next day and they read me a long list of error codes that had been experienced, and all of them went back to this PCM problem, apparently, as described in TSB 10-18-10. The contact stated that at times when the vehicle was stopped at a traffic light, it would accelerate slowly upon take-off. The contact owns a 2005 Ford Five Hundred. I Have A 1994 Ford Explorer Xlt 4wd 6 Cyl, That Is Not Wanting To Start, It Has 1/4 Tank Of Gas; The Engine Tries To Kick Over But It Is https://www.2carpros.com/articles/symptoms-of-a-bad-crankshaft-sensor, https://www.2carpros.com/articles/crankshaft-angle-sensor-replacement. It was very unsafe. The vehicle was taken to an independent mechanic for diagnosis where the vacuum operative valve behind the throttle body was replaced. So, OPTION B.spend $200 for the used cable, let the Ford tech. Blinkers do not work. No warning what so ever. Engine Shutdown While Driving 2005 Ford Escape (Page 1 of 2) This problem may be covered under warranty. No lights, no dash lights, no radio, no a/c, no wipers and the car was in drive at 40 mph. which is now bankrupt from what I have been told. 2. Has this guy ever hear of stored fault codes? But the alternate is putting our 14.2 at idle.when this issue happens every accessory shuts down except headlights and the engine. I had no warning was in bad traffic from a collision just up ahead when the car just died. They said it was bad ignition coil packs. Please issue a recall on the instrument panel replacement. bumpy road ) its now done it 5 times, Ford looked at it once and drove it for 20 miles, said they couldnt recreate the problem, has anyone experianced anything of . When in drive it hoes away. This was the first of many times this occurred! Continued to drive and the instrument cluster began working a few moments later. 2005 Ford Explorer Engine Stalls/Shuts Off While Driving The mechanic drained the air conditioning system however, the failure was not corrected. I just bought the vehicle 6 days prior to the problem. last month in January my Five Hundred had other issues. Gauges drop check engine light comes on then wrench light then one shaped like a car n starts loosen power. It started back up and ran fine. The vehicle was taken to a dealer who diagnose that the throttle body sensor needed to be replaced. Limp mode. Last week I was driving down my street and the engine stalled. Apparently this is a ongoing problem with these vehicles. They could not get any codes out of it so then the guessing game started. While driving approximately 50 mph, the contact stated that the vehicle stalled. An employee of the store that was on the back, left side of the car pointed towards and said, look! 05 500 Limited, AWD, CVT Amp and 2, 12 inch boomers in the trunk. Days lights flicker. It may be an electrical issue causing your Mustang to shut off, so your Ford dealer will be able to diagnose it. You must be able to get it stopped on the side of the road and shut the car off and then restart it to correct the problem for a short period of time. Is there anyone else that has had this problem. Sometimes the car will stall when the rpm's are dropping down. Consumer stated the left front head light caught on fire spontaneously while having been parked for 30 minutes in the garage and engine was off. The failure occurred intermittently while driving at any speed. I have a 2007 Ford Five Hundred with 21K miles. statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. See http://www.rockauto.com/catalog/moreinfo.php?pk=443736&cc=1431199. Looking at it, I could see it was the security light on the bottom side of the mirror; it was completely melted and fused to the mirror housing- a bubbly mess of plastic. The contact owns a 2006 Ford Five Hundred. The failure occurred intermittently while driving at any speed. Lucky for us, my daughter works for Ford. They issued memo's to their stores, (which I have copies of) but NEVER sent a letter to the owners. And now the dash shows check engine and reactions control and abs lights. We were going approximately 45 miles an hour on a two lane road through the mountains when my Explorer decides to turn off. Glad it's being fixed. 2006 Ford Five Hundred. Learn More Get it fixed today at a shop near you Good news! WOW!! Instrument cluster intermittently went dark and/or gauges went to zero/off positions, we pulled over to see if exterior lights worked and all did, as well as blinkers and flashers, but we noted that reverse lights were now on. The car is essentially un-drivable, because we cannot count on it to get to us work on time or safely. Vehicle then began showing random warning lights including "check engine", which was diagnosed first time as low fuel level sensors a & b. The failure and current mileage was 138,000. In my opinion, the computer caused the problem due to a very deficient manufacturing of it. Towed it to the dealer and the dealer spent over 6 hours to come to the conclusion that throttle body needed to be cleaned and pcm reprogrammed/updated. Have a 2005 Ford Escape on my out of town car stopped. In addition, the vehicle would suddenly stall and the fail safe engine sensor indicator illuminated on several occasions. Also please check out the This is a fantastic car! I had a bad no-start situation because the key was only working when inserted just the right way. The contact stated that while driving 60 mph, the fail safe mode activated, causing the vehicle to stall. Our car stalls while driving. If the computer loses the signal from this sensor, the computer sees no reason to operate the ignition and fuel systems so the engine shuts off. Cluster will Randomly shut off while driving? - Ford F150 Forum Cluster panel just shuts off while running and can't use air, radio, windows, locks, seats, etc. The contact stated that while at a stop light, the vehicle stalled without warning and shifted into reversed independently. Happens running driving and sitting still. Worst car ive ever bought second major incident that has happend since I got yhe car. Started while going down the expressway now constant. The failure mileage was 75,000 and the current mileage was 134,000. a sodering defect or electrical short draining battery, it's obviously a vehicle defect. The failure and current mileage was 94,000. It should be a recall. Im sure some people have been insured but are still unaware of cars deadly issues.FORD U SUCK!!!!! So, OPTION A..get a junkyard to cut off the end for $50 and splice/heat shrink on to existing cable. But I can't reset driver controls until doors show closed. Had it towed to the garage and he called me with you blew out the computer and 3 coils? This car has had so many issues, never again will I buy a FORD!! I called her and had her send the part over at HER PRICING of $820 total. FORD FIVE HUNDRED 2005 OWNER'S MANUAL Pdf Download It took at least three tries to get the truck restarted. 2005 Ford Five Hundred Review - NewCarTestDrive While driving dash lights, speedometer, tachometer, gas level, and temperature go out for several minutes at a time. Shutting off while driving! I didn't even make it home. My car has roughly 62,000 miles on it. It isn't far fetched that this electrical issue with failed safeguards could have resulted in far more injury than my slightly burned fingers. Did not fix problem. Although the car is ten years old now, it is really very low in mileage so as to face this kind of problem. Why can't ford be held acountable for thjese and fix them at no charge. Thanks for the update. The car now sits in my driveway where it was towed to and sits for safety reasons. Find solutions to your toyota ecu reset procedure question. While driving the car exhibits the following symptoms: dies for anywhere from 10-45 seconds, regain power and continues to work. 2005 ford five hundred. The car will just shut down all Have changed the throttle body and accelerator, n both sensors. 2005 FORD Five Hundred - Center for Auto Safety . The car will just shut down all lights except headlights and it will still run. The vehicle was towed to the contact's residence. The contact owns a 2005 Ford Five Hundred. While at idle my car would sputter. This vehicle has had a surging and stalling issue ever since it was purchased. I had my air conditioner on and we were only traveling at 5-10 mph. Oil was present in the engine and no other major issues seemed to be present before this one. Fuel Pump Problems: Car Stalls While Driving. Code Is P0191, - 2CarPros Members can start their own topics & subscribe to topics SOLVED: 2005 ford 500 shuts off while driving - Fixya The contact stated that the vehicle stalled without warning while driving 30 mph. The contact stated that while driving 20 mph, the vehicle started to lunge forward and backward before stalling. Till car stops, but it restarts when plugged back in without turning car off or removing key - therefore it must be a different failure. I see someone already pointed out no recall on this problem. I am very good to my car so now what. Ford Five Hundred owners have reported 25 Car stalled out 2 times on the way to the dealer. Please note that whenever the vehicle is on park and put into reverse, the higher acceleration takes place. The technician stated that the motor mount would need to be replaced. A service station diagnosed the problem and found an electrical short in a computer module which controls the radiator fan. I managed to get the dead metal off the road and into a store parking lot. The vehicle was not further repaired. When I Start It It Sputters. .Started up to drive home started & chugged, stepping on gas has no effect. the car could stall at anytime while driving putting myself and my family at risk, I don't think much of this automobile company for not standing behind there product, I will never recommend a Ford vehicle to friends,family or even my worst enemy never never again!!!!. 5 screws if I remember correctly. Cluster panel just shuts off while running and can't use air, radio, windows, locks, seats, etc. Follow directions how to clear failsafe and implement them. They basically didn't know what was going on with the exception of first replacing the PCM for $1200 at Fords cost. 2006 Ford Five Hundred Limited Shuts Off While Driving - Ford Taurus I was stopped at an intersection. The most expensive option available on the Five Hundred is all-wheel drive, but for $1,700 you get sure-footed traction for inclement weather and for mild off-pavement excursions as well as a continuously variable transmission, or CVT, that provides seamless operation and 19 mpg in town and 26 on the open road. I will never buy another Ford vehicle ever again!!!!!! statistics and reliability analysis of Ford Five Hundred, all problems of the 2006 Ford Five Hundred, all problems of the 2005 Ford Five Hundred, all problems of the 2007 Ford Five Hundred. The contact coasted the vehicle to the side of the road, turned it off and restarted it. Ford should be very glad that there was not an accident at 70 mph. It was very shaky. Powered by Discourse, best viewed with JavaScript enabled. It is easy to replace. I have half my oil life left. per internet research this is happening in several Ford models and stems from a bad solder joint. It is completely random and you never know when or if it will happen. Changing the fuse fixed the problem. Turns on and off intermittently. I've seen more electrial issues that turned out to be a weak battery. To perform this procedure, a Toyota hand-held . Before I buy another vehicle, I'll be sure to check online to discover how well the manufacturer took care of problems. It was very cold and snowy out. Wont shift from first gear after cluster panel shuts off. Then the next day I got the wrench and a check engine light. All the issues pointed @ a PATS problem. While reversing my car it will all of a sudden accelerate quickly on its own, I immediately step on the brakes and my car stalls. this is on a 2007 Ford 500, low miles. Engine light, oil light and something else came on. It has happened while slowing into a parking space, backing up, pulling away from stopping at a light or stop sign. 6.0L Power Stroke Diesel - 6.0 randomly shuts off - 04 with 170k miles. Had This Problem Approx 1 Yr Ago. While braking, the car will lurch and I mean really jump forward (or also in reverse) while rpm's surge/rev extremely high causing me to press very,very hard on the brakes at times slamming down to keep the car from going out of control by itself. Ford Five Hundred - Wikipedia Turned off the engine. While driving 60 mph, the vehicle failed to accelerate and the power train wrench icon illuminated. Door froze shut and ever since manually opening the message center states driver door ajar and passenger door ajar and they are not. Thank God it was all down hill. Wont shift from first gear after cluster panel shuts off. It Now Won't Even Start A Little, The Warning Says Low Oil Pressure. Go to another state & leave it there. finally got it started by holding brake and pushing on accelerator while putting it into drive so that it would not stall out. The car was driven from Florida to Philadelphia with no problems and it had its regular inspections. I have an 06 4x4 that shuts off at least 4 times a week and I have to put it in N to restart then I'm good for the rest of the day. The vehicles electronics completely shut off while driving at freeway speeds. In addition, the vehicle would suddenly stall and the fail safe engine sensor indicator illuminated on several occasions. I would like Ford to take some responsibility as this seems to be happening to most 500's and it is well known by many but not acknowledged by Ford. The manufacturer was not notified of the failure. It turns out it is a faulty instrument cluster, just like the TSB mentioned. I have read that you can report problems like this to the NHTSA and if there is enough complaints that they will investigate it and from what I hear this problem is very common. While driving approximately 70 mph, all of the gauges on the instrument cluster stopped functioning and displayed readings of zero. I was in a lot of traffic, 2 lanes and I was in the left lane. The vehicle was not repaired. When I got the car to the shop, they tried to turn the engine over with a breaker bar, and could not get it to turn. I know your car is a 2007 , but is it possible it was older stock when registered and is affected with this ? The contact owns a 2005 Ford Five Hundred. Ford Focus Shuts Down While Driving (Common Causes) The vehicle was not repaired. Still no fix. If the key is not removed, it will not restart. I coasted to a stop and restarted the car. Signal lights melted and quit working. Here is a screen capture of the Special Service Message. Replaced rail sensor (code it threw) fuel relay, fuel filter, and fuel pump. SET YOUR VEHICLE Get an exact fit for your 2007 Chevrolet Silverado 1500 Make Model. The repair of the whole cluster panel is not cheap. On the dash board "fail safe engine mode" appears on my console. Get notified about new defects, investigations, recalls & lawsuits for the. 2006 Ford Mustang Shuts Off While Driving? The batt light goes on and the entire instrument cluster (spedo fuel turbo temp etc ) shuts off .. when it's off the climate control won't work and the sun roof won't work . Car drives on its own! I can fix the ford 500 at 4 days of replacing parts and research I added throttle body and sensor, gas pedal, map sensor, fuel rail sensor, plugs, intake gasket, egr, removed the entire exhaust system and removed the inside of the converter in front of the muffler and made sure exhaust was totally clear, new fuel filter, new fuel pump. #1 Yesterday, on 2 separate occasions, my car shut off completely while I was driving it. The Fora platform includes forum software by XenForo. Yesterday the check engine light came back, and the car was running poorly (creeping when first off brakes, not up shifting), when the dash was operable it showed alternating check engine/check transmission warnings, and vehicle was surging/lagging noticeably at highway speeds. Drove it for a day and then had the same problem in traffic when at low rpm, with children in car at intersection car stalled out! However, none of these parts are available due to being on backorder. Finally got on the highway and got home. Service Engine light then came on and so I got it started again and took it immediately to the nearest auto shop. 1 of the 3 connectors to the PCM on the wiring harness was so melted it could not be used. This happens frequently almost daily in the summer. So the first thing I did was open the hood and make sure nothing was on fire. I looked on here and it seems a lot of Escapes have the same problem. The failure mileage was 60,000 and the current mileage was 121,000. I purchased the car used with the understanding that it had some issues with a misfire. The contact owns a 2005 Ford Five Hundred. The mechanic told me this might just be a one time glitch. Truck has to be shut off and started with cluster on. only code that comes up is number 6 injector. I cannot believe they knew about this issue and moved on. 5.4 shutting off while driving. Then starts back up? - Ford Truck Please keep us posted on what you find. The most common reasons a car shuts off while driving are a bad crankshaft position sensor or fuel supply problems. HELP! The Ford shuttle just arrived, must go. The dealer was notified of the issue but the vehicle was not repaired. Who buys a car to keep dumping cash into it & burdening people for rides?????? Drove for approx 10 miles and then it started running rough again and appeared to be losing power. After placing fuel in the vehicle, white smoke emerged from the engine compartment. This is dangerous and should be an electrical recall. At first I thought it may be the battery, which would also cause the car to die. So now were waiting to see what Sat. [By the way it was also sputtering}. Got it installed, volt/ohm tested the harness and also tested the new PCM and everything looked good. I am now relatively convinced that I will not be persuaded to buy another Ford in the foreseeable future, until they learn that they must keep pace with foreign competition on quality and engineering. I have been reading a lot on this car and its problems people have come into and wonder why no recall has been issued. After all of this car still gave check engine and wrench light and car still stalled out and had no power. on October 19, 2016. it is extremely dangerous! This is dangerous and should be an electrical recall. Me and my seven year old daughter was in the car. We thought is may have been the gas. Oil and brake light illuminate constantly. Also lost power steering, and abs breaks. I put it in park and turned off the vehicle; opened the trunk; and looked up startled when a guy sitting nearby said that my car was smoking and on fire (about 10 seconds since I switched the car off and got out). Part of an ongoing series of issues with this vehicle (see earlier reports), initial symptom was the dash lights & needles shutting off intermittently (but now for extended periods). I have a 2007 Ford Five Hundred with 21K miles. I mean it can't be normal wear and tear or for that matter why did I have notice of a problem from my system check. When shopping for a new suv I likely won't even consider a Ford. Ask your Ford dealer. This problem may be covered under warranty. GAUGE CLUSTER ISSUES SOLVED HERE! - Ford Power Stroke Nation Noticed a million other complaints the same should this not be investigated? This is the third time that this has happened. I do not think it should be my responsibility to pay for this since the part was recalled !!! Then later down the road it will do it again. The batteries on overage only last around 2 years. We have since talked to several Ford dealers including Ford motor company , they all said it was our responsibility to fix the problem. Complete Electrical Failure While DrivingHELP HELP - Ford Taurus Forum FORD FIVE HUNDRED OWNER'S MANUAL Pdf Download | ManualsLib The VIN was unavailable. This process repeats on and off over time. I will never buy another Ford vehicle ever again!!!!!! Ford Five Hundred Questions - 2005 ford 500 wrench light, changed 2007 Silverado Blower Motor Resistorcom blower motor resistor dorman In case Ford needs good reason to do recall how does I fear driving after stalling no warning on freeway and have 3 people almost hit me on Tuesday at 130pm 8/5/14 check ktvu bay area news see what traffic was like yep could have been killed. There are countless others who have filed complaints and concerns regarding this very issue. The contact also stated that while in park, the vehicle would attempt to accelerate. Also, when using cruise control, the whole car shakes and stutters slightly when going up or down very slight inclines. Aftermarket is not to be trusted. I had my Ford 500 3mos, at first all dash board lights would go outand maybe come back on the same day. The failure mileage was 68,780.